Subaru-robin EH90 User Manual

EH99EH99EH90/ EH99OHV Gasoline EngineEMD-EU9099September 2013

10and cylinders. Please check with your authorized Subaru en-gine service dealer for assistance. Only operate the engine after it has cooled and the c

11items to maintain. The engine will not run properly and may be damaged if it is run with a dirty air cleaner system.Service or replace the paper air

12each year, whichever comes fi rst. This will help the engine to start easier and run better. 1 Stop the engine and pull the spark plug wires off o

13Figure 11 NOTE: The rocker arm jam nut must be held in place as the pivot ball stud is turned. When the valve clearance is cor

14MAINTENANCE SCHEDULEEvery 8 Hours or DailyEvery 50 Hours or YearlyEvery 100 Hours or YearlyEvery 500 Hours or YearlyEvery 1000 HoursClean engine and

15STORAGE INSTRUCTIONSThis engine should be started at least once a month and run for at least 10 minutes. If this cannot be done and the equip-ment m

16TROUBLESHOOTINGPROBLEM CAUSE CORRECTIONEngine will not start; or starts and runs rough1. Clean or replace air cleaner2. Fill fuel tank3. Drain fue

17WIRING DIAGRAMMSGBL30AMP FUSEBLUEHIGH TEMPERATUREWARNING ALARM WHITEWHITEYELLOWTACHOMETER/HOUR METER(OPTION)SPARK PLUGSPARK PLUGIG COIL #2OFFRUNIG C

Limited Engine Warranty(Effective with engines purchased in U.S.A. and Canada after March 1, 2012)Subaru Industrial Power Products, a division of Fuji

Notice : FEDERAL EMISSION COMPONENT DEFECT WARRANTY applies only to engines sold in the United States and U.S. Territories.Notice : To the engi

Please take a moment to register your product to ensure easy warranty qualifi cation and product updates. Please register online at: www.SubaruPower.

FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE - This emission warranty is applicable in all States, except

OWNER’S WARRANTY RESPONSIBILITIESAs the engine owner, you are responsible for the performance of the required maintenance listed in your owner’s manua

Part Number 0K5115

CONTENTSSAFETY PRECAUTIONS ... 5

4SYMBOLSUSA and CANADA onlyRead INSTRUCTIONSFOR USE before use.The engine emits toxic gas that can kill you in minutes.Do not run in an enclosed area.

5The safety alert symbol ( ) is used with a signal word (DANGER, CAUTION, WARNING), a pictorial and/or a safety message to alert you to hazards. D

6SAFETY PRECAUTIONSBEFORE OPERATING• Gasoline is highly FLAMMABLE and its vapors are EXPLOSIVE. Do not permit smoking, open fl ames, sparks or hea

7Use only high quality detergent oil rated with an API service classifi cation SJ or higher. DO NOT use oil designated “For Diesel Engines Only”. The u

8 Never fi ll the fuel tank indoors, or when the engine is running or hot. Wait 1 minute before refi lling. Do not light a cigarette or smoke when

9 • Place engine on level surface. • Clean area around oil fi ll and remove oil fi ll cap and dipstick. • Wipe dipstick clean. Reinstall and ch